Lubrication Specs - CJ-5

ITEM TO BE LUBRICATED	FREQUENCY* 1000 miles = 1.600 km.	QUANTITY			LUBRICANT
		U.S.	Imperial	Metric	Type	GRADE
						Summer	Winter
Chassis Bearings	Each 1000 miles	As required			Chassis Lubricant	No. 1	No. 0
Spring Shackle Bushings & Spring Pivot Bolt Bushings	With lube fittings: Each 1000 miles Without lube fittings: No lubrication	As required			Chassis Lubricant	No. 1	No. 0
Universal Joints Propeller Shaft Front Axle Shaft	Each 1000 miles Check each 1000 miles Change each 12.000 miles	As required			Universal Joint Lubricant	No. 1	No. 0
Steering Gear Housing	Check each 1000 miles	As required			MIL-L-2105B	SAE 80	SAE 80
Rear Wheels	Sparingly each 1000 miles	As required			Wheel Bearing Lubricant	No. 2	No. 2
Front Wheels	Disassemble to lubricate each 6000 miles	As required			Wheel Bearing Lubricant	No. 2	No. 2
3-Speed Transmission and Transfer Case	Check each 1000 miles, change each 10,000 miles	6 1/2 pts.	5 1/2 pts.	3 ltrs.	GL-4	SAE 90	SAE 80
Transmission*	Check each 1000 miles,	6 3/4 pts.	5 3/4 pts.	3,2 ltrs.	GL-4	SAE 90	SAE 80
Transfer Case*	Change each 10,000 miles	3 1/2 pts.	3 pts.	1,7 ltrs.	GL-4	SAE 90	SAE 80
Differentials:
Front	Check each 1000 miles,	2 1/2 pts.	2 pts.	1,2 ltrs.	MIL-L-2015B*	SAE 80	SAE 80
Rear	Change each 10,000 miles
Speedometer Cable	Disassemble to lubricate each 12,000 miles	As required			Graphite Grease	Light
Distributor:
Oiler	Each 1000 miles	Several Drops			Engine Oil	Same as engine
Wick	Each 1000 miles	One Drop			Engine Oil
Pivot	Each 1000 miles	One Drop			Engine Oil
Cam	Each 1000 miles	2 c. c.			Cam Lubricant
Air Cleaner	Each 2000 miles	1 1/4 pts.	1 pt.	591,4 cm	Engine Oil	Same as engine
Generator	Each 1000 miles	2-4 Drops			Engine Oil	Same as engine
Engine	Change each 2000 miles	4 qts.**	3 1/2 qts.	3,8 ltrs.	Engine Oil	Same as engine

Not lower than 32 degrees Farenheit (0 degrees Celsius), use SAE 30 or 10W-30

*For Powr-Lok differential use only Willys Powr-Lok Differential Oil, Part No. 94557

**When oil filter is changed at the same time, add one quart

(Note - 4-Speed transmission and transfer case (optional on a CJ-5 and 6) require separate lubrication of each unit.)

* Excerpt from the Service Manual for Universal Jeep Vehicles page 10